JW030A-M Lineage Power, JW030A-M Datasheet
![no-image](/images/manufacturer_photos/0/3/387/lineage_power_sml.jpg)
JW030A-M
Specifications of JW030A-M
Available stocks
Related parts for JW030A-M
JW030A-M Summary of contents
Page 1
... These power modules feature remote on/off, output sense (both negative and positive leads), and output volt- age adjustment, which allows output voltage adjustment from 80% to 110% for the JW030A-M, D-M, F-M, G-M and 60% to 110% for the JW030B-M, C-M of the nominal output voltage. For disk-drive applications, the JW030B-M Power Module provides a motor-start surge current The modules are PC board-mountable and encapsulated in metal cases. The modules are rated to full load at 100 ° ...
Page 2
... Min V — – –40 stg — — — — Symbol Min Typ — — I, max — — I — — — 50 March 26, 2008 Max Unit 80 Vdc 100 °C 110 °C 500 Vdc 1500 V Max Unit 75 Vdc 1 0 — mAp-p — dB Lineage Power ...
Page 3
... B-M, C-M A-M, D-M, F-M, G-M B-M, C-M JW030D-M, F-M, G-M JW030A-M JW030B-M JW030B-M JW030C-M JW030D-M, F-M, G-M JW030A-M JW030B-M JW030C-M JW030D-M, F-M, G-M JW030A-M JW030B-M JW030C-M JW030D-M JW030G-M JW030F-M JW030A-M JW030B-M, C-M All 36 Vdc to 75 Vdc Inputs Symbol Min Typ ...
Page 4
... Isolation Resistance General Specifications Parameter Calculated MTBF ( max Weight 4 4 (continued) Device Code or Code Suffix JW030D-M, F-M, G-M JW030A-M, B-M, C-M All JW030D-M, F-M, G-M JW030A-M, B-M, C-M All Min — 10 Min ; °C) C — March 26,2008 Symbol Min Typ Max — ...
Page 5
... Lineage Power Device Code or Code Suffix All All All All All ; All All All D-M, G-M, F-M, A-M B-M, C-M JW030D-M JW030G-M JW030F-M JW030A-M JW030B-M JW030C-M 36 Vdc to 75 Vdc Inputs Symbol Min Typ Max I — — 1.0 on/off V –0.7 — 1.2 ...
Page 6
... Variation over Ambient Temperature Range 6 2.5 2.0 1.5 1.0 0 Figure 3. JW030D-M Typical Output (V) I 8-740(C) 3.0 2.5 2.0 1.5 1.0 0.5 0 100 Figure 4. JW030G-M Typical Output 8-852(C).a Data Sheet March 26, 2008 OUTPUT CURRENT, I (A) O Characteristics OUTPUT CURRENT, I (A) O Characteristics Lineage Power 8 9 8-1331( 8-2557(C) ...
Page 7
... 1.5 1.0 0 OUTPUT CURRENT, I Figure 5. JW030F-M Typical Output Characteristics OUTPUT CURRENT, I Figure 6. JW030A-M Typical Output Characteristics Lineage Power 0.0 0.5 1.0 1 Figure 7. JW030B-M Typical Output (A) O 8-1194( 0.0 0.5 1.0 1 (A) O Figure 8. JW030C-M Typical Output 8-737(C) JW030-Series Power Modules: 36 Vdc to 75 Vdc Inputs ...
Page 8
... OUTPUT CURRENT, I Figure 10. JW030G-M Typical Converter Efficiency vs. Output Current Figure 11. JW030F-M Typical Converter Efficiency 4.0 4.5 5.0 5.5 6.0 6.5 (A) O 8-1330( Figure 12. JW030A-M Typical Converter Efficiency 4.6 5.6 6.6 (A) O 8-2558(C) Data Sheet March 26, 2008 OUTPUT CURRENT, I (A) O vs. Output Current ...
Page 9
... O 8-743(C) Figure 16. JW030A-M, B-M, C-M Typical Output Voltage for a Step Load Change from 50% to 75% JW030-Series Power Modules: 36 Vdc to 75 Vdc Inputs Δ A/10 µs Δt 500 µs TIME, t (500 µs/div) 8-731(C).a Δ A/10 µs Δ ...
Page 10
... Voltage for a Step Load Change from 50% to 25% 102 100 Δ A/10 µs Δt 25 TIME, t (500 µs/div) Figure 18. JW030A-M, B-M, C-M Typical Output Voltage for a Step Load Change from 50% to 25% 10 100 500 µs Figure 19. Typical Output Voltage Start-Up when 8-732(C).a Signal Applied to Remote On/Off 500 µ ...
Page 11
... V (+) V (– – Figure 22. Output Voltage and Efficiency Measurement Test Setup Lineage Power Design Considerations Grounding Considerations CURRENT The case is not connected internally allowing the user PROBE flexibility in grounding. V (+) I Input Source Impedance V (-) I The power module should be connected to a low ac- impedance input source ...
Page 12
... Lineage Power36 Vdc to 75 Vdc Inputs Feature Descriptions Overcurrent Protection To provide protection in a fault (output overload) condi- tion, the unit is equipped with internal current-limiting circuitry and can endure current limiting for an unlim- ited duration. At the point of current-limit inception, the unit shifts from voltage control to current control. If the ...
Page 13
... With an external resistor connected between the TRIM and SENSE(+) pins (R ), the output voltage set adj-up point (V ) increases (see Figure 26). The following O, adj equations determine the required external-resistor value to obtain an output voltage change of %ý. JW030A-M, B-M, C-M: ⎞ %Δ V ⎛ ⎛ ⎞ 10 kΩ O, nom ...
Page 14
... MEASURE CASE TEMPERATURE ( CENTER OF UNIT AIRFLOW 76.2 (3.00) 101.6 (4.00) 203.2 (8.00) Figure 27. Thermal Test Setup March 26, 2008 12.7 (0.50) WIND TUNNEL WALL AIR- FLOW 203.2 (8.00) AIR VELOCITY AND AMBIENT TEMPERATURE MEASURED BELOW THE MODULE 19.1 (0.75) Lineage Power 8-1046(C) ...
Page 15
... With the known power dissipation and a given local ambient temperature, the appropriate air- flow can be chosen from the derating curves in Figure 34. For example, if the JW030A-M dissipates 6.2 W, the minimum airflow °C environment (200 ft./min.). 8 ...
Page 16
... Figure 35 shows the case-to-ambient thermal resis- tance, θ (°C/W), for these modules. These curves can be used to predict which heat sink will be needed for a particular environment. For example, if the JW030A-M dissipates heat °C environment with an airflow of 0.7 ms sink required can be determined as follows: where: 1 ...
Page 17
... AIR VELOCITY, ms Figure 35. Case-to-Ambient Thermal Resistance vs. Air Velocity Curves; Either Orientation Lineage Power Although the previous example uses 100 °C as the (continued) maximum case temperature, for extremely high reliabil- ity applications, one can use a lower temperature for max ...
Page 18
... Side View 12.7 (0.50) MAX Bottom View 5.1 (0.20) 50.8 (2.00) 35.56 (1.400) 18 57.9 (2.28) MAX V (+) I ON/ 61.0 OFF JW030A-M (2.40) MAX DC-DC Power Module CASE 36-75V 0.95A OUT MADE IN USA M3 V (-) I 0.51 (0.020) 5.1 (0.20) MIN 7.1 (0.28) STANDOFF, 4 PLACES 12 ...
Page 19
... M3 x 0.5 CLEARANCE HOLE, 4 PLACES (OPTIONAL) Device Comcode Code JW030D1-M 107670259 JW030G1-M 108448259 JW030F1-M 107587859 JW030A1-M 107587776 JW030B1-M 107587818 JW030C1-M 107587834 JW030D-M 107587842 JW030G-M TBD JW030F-M 107600546 JW030A-M 107584278 JW030B-M 107587800 JW030C-M 107587826 8-716(C) 19 ...
Page 20
... Lineage Power reserves the right to m ake changes to the produc t(s) or inform ation contained herein without notice. No liability is ass res ult of their use or applic ation. No rights under any patent acc om pany the sale of any oduct information. ...