ZFSM-101-2 CEL, ZFSM-101-2 Datasheet
ZFSM-101-2
Specifications of ZFSM-101-2
Related parts for ZFSM-101-2
ZFSM-101-2 Summary of contents
Page 1
... Simple Serial UART Interface • Over 65,000 network addresses This FreeStar (ZFSM-101-2) datasheet is based on the Freescale MC13202 transceiver IC. It replaces the old FreeStar (ZFSM-101-1) datasheet that was based on the Freescale MC13192 transceiver IC. This datasheet also highlights the changes made when migrating from the MC13192 (now obsolete) to the MC13202 transceiver IC. ...
Page 2
... ZFSM-101-2 with / Freescale MC13202 FreeStar FreeStar 100mW transceiver module PCB Trace Antenna ZFSM-101-2 ZFSM-101-2-B with / Freescale MC13202 Bulk (1 tray) ZFSM-101-KIT-1 100mW Freestar Module Kit Freescale MC13192 FreeStar ZFSM-101-2 Mins/Mults Status 200 pcs / 200 pcs Not Recommended 50 pcs / 50 pcs For New Design 1 ...
Page 3
... Kits, refer to the respective Development Kit user guides documents. (Available at CEL’s website: com/MeshConnect) To order a Development Kit, please contact your nearby CEL sales office or representatives. PA Enable ANT PA LPF Balun Balun FreeStar ZFSM-101-1 Kit is based on the MC13192 transceiver IC (Limited Availability). www.cel. FreeStar ZFSM-101-2 Page 3 ...
Page 4
... Pin Signal & Interfaces Pin Definitions........................................................................................................................................................................................ Connector Legend.................................................................................................................................................................................. Connector Configuration....................................................................................................................................................................... Radiation Patterns.................................................................................................................................................................................. Example Interface Diagrams.................................................................................................................................................................. Module Dimensions................................................................................................................................................................................ Module Footprint.................................................................................................................................................................................... Module Keepouts.................................................................................................................................................................................... Processing ......................................................................................................................................................................................... Quality .................................................................................................................................................................................................. Agency Certifications ................................................................................................................................................................... Shipment, Storage & Handling ................................................................................................................................................. References & Revision History ................................................................................................................................................. 18 FreeStar ZFSM-101 ...
Page 5
... TRANSCEIVER IC The FreeStar ZFSM-101-2 module (MC13202 based module) replaces the ZFSM-101-1 module (MC13192 based module). The key differences between the MC1319x series and the MC1320x series are the addition of an internal transmit/receive (TR) switch to the MC1320x design and some receiver design changes that require a few register setting changes for opti- mal performance. Default condition of T/R switch is disabled ...
Page 6
... Power Supply Voltage (Vdd) Input Frequency Ambient Temperature Range Logic Input Low Voltage Logic Input High Voltage Value Unit 3.6 Vdc +10 dBm -55 to 125 ºC Min Typ Max Unit 2.8 3.3 3.6 Vdc 2405 2480 MHz - ºC 0 30% Vdd V 70% Vdd Vdd V FreeStar ZFSM-101-2 Page 6 ...
Page 7
... FreeStar ZFSM-101-2 Min Typ Max Unit 2400 2483.5 MHz 1 100 mW -91 dBm 250 kbps 19.2 kbps 2.8 3 pins 16 channels 165 80% Vdd Vdd ...
Page 8
... AND FIRMWARE DEBUG MASTER RESET, ACTIVE LOW SCI2 TXD2 (SERIAL COMMUNICATION INTERFACE 2, TRANSMIT DATA) SCI2 RXD2 (SERIAL COMMUNICATION INTERFACE 2, RECEIVE DATA) RESERVED APPLICATION TRANSMIT DATA OUTPUT (SCI1, TXD1) APPLICATION RECEIVE DATA INPUT (SCI1, RXD1) GROUND GROUND GROUND GROUND GROUND GROUND FreeStar ZFSM-101-2 Page 8 ...
Page 9
... PDT3 PDT4 PDB0 PDB1 VCC GND MODE0 Note: The PIN Numbering begins at top left-hand side with pin number 1 and follows counter-clockwise about the perimeter of the module GND GND GND GND GND GND RXD TXD PTC5 PTC1 PTC0 FreeStar ZFSM-101-2 Page 9 ...
Page 10
... RADIATION PATTERNS FreeStar Rev B 2440 MHz Device Orientation Polarization (V) vertical (V) horizontal (H) vertical (H) horizontal (F) vertical (F) horizontal Toatal Avg. Gain (dB) Vertical Horizontal Flat Gain (dB) Max Avg 0.60 -1.72 -7.27 -12.37 -4.00 -10.91 0.02 -5.90 -6.62 -13.52 0.85 -4.67 -3.15 FreeStar ZFSM-101-2 Page 10 ...
Page 11
... EXAMPLE INTERFACE DIAGRAMS Sample Connection Diagram when Using Serial Interface Sample Connection Diagram when Using Host Processor Interface FreeStar ZFSM-101-2 Page 11 ...
Page 12
... FOR REFERENCE ONLY 0.047” Recommended Host PCB Board Edge 1 1.115” 0.098” Pitch Throughout 0.068” 0.047” 30 0.098” (2.5mm) Pitch Throughout 0.060” TYP 30 Places TYP 30 Places 0.090” (2.5mm) 0.068” 0.885” FreeStar ZFSM-101-2 Page 12 ...
Page 13
... OF HOST PCB ALLOWED WITHIN 0.100” OF MODULE • NO COMPONENTS ON EITHER TOP OR BOTTOM SIDES OF HOST PCB ALLOWED IN THIS AREA • NO COPPER/TRACES ALLOWED ON ANY LAYER OF HOST PCB IN THIS AREA FreeStar ZFSM-101-2 COPPER AND COMPONENT KEEPOUT 0.265” RECOMMENDED MODULE EXTENSION OVER EDGE OF HOST PCB 0.100” ...
Page 14
... Only a single reflow soldering process is encouraged for host boards. Wave Soldering If a wave soldering process is required on the host boards due to the presence of thru hole components, only a single wave soldering process is encouraged. FreeStar ZFSM-101-2 3º/sec max 150ºC 200ºC 60-120 sec 217º ...
Page 15
... CEL modules are 100% factory tested for RF and DC performance. In addition, every production lot is sample tested for compliance with CEL’s high quality and performance standards. CEL builds quality into our products giving our customers the confidence when integrating our products into their systems. FreeStar ZFSM-101-2 Page 15 ...
Page 16
... Health Canada limits for the general population. Consult Safety Code 6, obtainable from Health Canada's website: http://www.hc-sc.gc.ca/ewh-semt/pubs/radiation/99ehd-dhm237/index-eng.php EMC Certification FCC Part 15.247 Module Certified (Portable) EN 300 328 1 Certified / CE Approved Moisture Sensitivity Level (MSL) MSL 3, per J-STD-033 FreeStar ZFSM-101-2 Page 16 ...
Page 17
... The CE marking must be affixed visibly, legibly and indelibly. Since the 868 MHz band is not harmonized by a few countries throughout Europe, the Restriction sign must be placed to the right of the “CE” marking as shown in the picture Australia Certification Number: AS/NZS 4268 FreeStar ZFSM-101-2 Page 17 ...
Page 18
... While CEL endeavors to enhance the quality, reliability and safety of CEL products, customers agree and acknowledge that the possibility of defects thereof cannot be eliminated entirely. To minimize risks of damage to property or injury (including death) to persons arising from defects in CEL products, customers must incorporate sufficient safety measures in their design, such as redundancy, fire-containment and anti-failure features. FreeStar ZFSM-101-2 Page(s) N ...