T64-4E2H-JDE MAGNETROL [Magnetrol International, Inc.], T64-4E2H-JDE Datasheet
T64-4E2H-JDE
Related parts for T64-4E2H-JDE
T64-4E2H-JDE Summary of contents
Page 1
Liquid Level Control ...
Page 2
Read this Manual Before Installing Conventions Used in this Manual WARNINGS Safety Messages Low Voltage Directive Notice of Trademark, Copyright, and Limitations Warranty Quality Assurance ...
Page 3
Introduction 2.0 Installation 3.0 Reference Information Side Mounting Liquid Level Controls ...
Page 4
Pivot Return 3 Spring 2 1 Pivot Float Pivot Return spring Swing out position ...
Page 5
Fulcrum Pin Fulcrum Bar Lock Nut Float Stem ...
Page 6
Screw Screw Set Screw ...
Page 7
Internal Circuit (Left) Switch Load Load Close on low level Common Close on high level Load Load Line Internal Circuit (Right) Switch OBSERVE ALL APPLICABLE ELECTRICAL CODES AND PROPER WIRING PROCEDURES. Close on low ...
Page 8
Guide washer Upper jam nuts B Lower jam nuts Magnetic sleeve Pivot Magnetic sleeve stem control Pivot Float stem length minus approx. 3/4" A High level Differential Œ Low level Float Œ Ž ...
Page 9
...
Page 10
Minimum nozzle opening C of control L L Œ Ž Switch mechanism actuates on rising level Level differential Switch mechanism actuates on falling level Ž ...
Page 11
Keep control clean. Inspect switch mechanisms, terminals, and connections monthly. ...
Page 12
Inspect entire unit periodically. NEVER NEVER NEVER NEVER ...
Page 13
...
Page 14
...
Page 15
Π...
Page 16
This dimension equals B stem length plus float length minus 2.50 (64). A 4.50 (114) C plugged D 2.25 (57 control L L 4.50 (114) Square flange 2.50 (64) dia. float (std) This dimension equals float stem length ...
Page 17
This dimension equals stem length plus float length minus B 2.54 (65). 4.50 (114) A Min. Nozzle Opening 2.31 (59 plugged 3.00 Male pipe threads 2.25 Maximum nozzle (57) length (L) to inside of tank "A" mechanism actuates ...
Page 18
Œ Ž Œ Ž ...
Page 19
Tandem Switch Mechanisms Serial No. Tag (Ref (T52 and T57 (T62 and T67) Threaded 11 12 ...
Page 20
ΠΠΠ...
Page 21
Œ Œ Œ Ž Ž Ž ...
Page 22
Next Page) Π...
Page 23
Class I, Div Class I, Div EEx Groups C&D Group B “ “ ‘ Class I, Div 1 Class I, Div 1 NEMA 4X Groups C&D ” ATEX Class I, Div ...
Page 24
Service Policy 5300 Belmont Road • Downers Grove, Illinois 60515-4499 • 630-969-4000 • Fax 630-969-9489 • www.magnetrol.com 145 Jardin Drive, Units 1 & 2 • Concord, Ontario Canada L4K 1X7 • 905-738-9600 • Fax 905-738-1306 Heikensstraat 6 • B 9240 ...