450-0104 LS Research, 450-0104 Datasheet

Page 1

... Mobile Accessories  All Bluetooth Wireless Applications ORDERING INFORMATION Order Number 450-0104 450-0104R 450-0105 The information in this document is subject to change without notice. 330-0100-R1.0 TiWi-uB2 Bluetooth Module DESCRIPTION LSR would like to announce a low-cost and low- power consumption module which has all of the Bluetooth functionalities ...

Page 2

... The information in this document is subject to change without notice. 330-0100-R1.0 Order Number 2.4 GHz Dipole Antenna with Reverse 001-0001 U.FL to Reverse Polarity SMA Bulkhead 080-0001 Table 2 Module Accessories Copyright © 2012-2013 LS Research, LLC TiWi-uB2 Module DATASHEET Description Polarity SMA Connector Cable 105mm Page ...

Page 3

... BLOCK DIAGRAM Figure 1 TiWi-uB2 Module Block Diagram The information in this document is subject to change without notice. 330-0100-R1.0 Copyright © 2012-2013 LS Research, LLC TiWi-uB2 Module DATASHEET Page ...

Page 4

... SOLDERING RECOMMENDATIONS ................................................................................ 16 Recommended Reflow Profile for Lead Free Solder ............................................................................. 16 CLEANING ......................................................................................................................... 17 OPTICAL INSPECTION ..................................................................................................... 17 REWORK ........................................................................................................................... 17 SHIPPING, HANDLING, AND STORAGE ......................................................................... 17 Shipping ..................................................................................................................................................... 17 Handling ..................................................................................................................................................... 17 Moisture Sensitivity Level (MSL) ............................................................................................................. 17 The information in this document is subject to change without notice. 330-0100-R1.0 Copyright © 2012-2013 LS Research, LLC TiWi-uB2 Module DATASHEET Page ...

Page 5

... CE Notice ................................................................................................................................................... 24 Declaration of Conformity (DOC) ............................................................................................................ 24 BLUETOOTH CERTIFICATION ......................................................................................... 24 MECHANICAL DATA......................................................................................................... 25 Tape & Reel Dimensions .......................................................................................................................... 27 Tray Dimensions ....................................................................................................................................... 28 DEVICE MARKINGS .......................................................................................................... 29 Rev 1 Devices ............................................................................................................................................ 29 Rev 2 Devices ............................................................................................................................................ 29 CONTACTING LS RESEARCH ......................................................................................... 30 The information in this document is subject to change without notice. 330-0100-R1.0 Copyright © 2012-2013 LS Research, LLC TiWi-uB2 Module DATASHEET Page ...

Page 6

... FOOTPRINT AND PIN DEFINITIONS Figure 2 TiWi-uB2 Module Schematic View The information in this document is subject to change without notice. 330-0100-R1.0 Figure 3 TiWi-uB2 Module Footprint View Copyright © 2012-2013 LS Research, LLC TiWi-uB2 Module DATASHEET Page ...

Page 7

... PCM FRAME SYNCH (IF NOT USED, DO NOT CONNECT CONNECT 3 (DO NOT CONNECT) O LOGGER OUTPUT GND GROUND PI = Power Input I = Input O = Output IO = Bi-directional Input Output Port RF = Bi-directional RF Port GND=Ground Table 3 TiWi-uB2 Pin Descriptions Copyright © 2012-2013 LS Research, LLC TiWi-uB2 Module DATASHEET Description Page ...

Page 8

... Stressing the module beyond these limits may result permanent damage to the module that is not covered by the warranty. The information in this document is subject to change without notice. 330-0100-R1.0 Description Table 4 Absolute Maximum Ratings Min Typ 2.2 3.3 1.62 1.8 Copyright © 2012-2013 LS Research, LLC TiWi-uB2 Module DATASHEET Min Max Unit -0.5 5.5 V -0.5 2.145 V ...

Page 9

... Operating Humidity 10% to 95% Non-Condensing Storage Humidity 5% to 95% Non-Condensing 0.18 g +/- 0.01g Table 6 General Characteristics Master/Slave Master/slave Master/slave Master/slave Master/slave Master/slave Master/slave Master/slave Master/slave Master/slave Master/slave Master/slave Table 7 Bluetooth Power Consumption Copyright © 2012-2013 LS Research, LLC TiWi-uB2 Module DATASHEET Average Current Unit 2 11.5 mA 8.3 mA 38 ...

Page 10

... Empty Tx/Rx LL packets Table 8 Bluetooth Power Consumption Typ 47.1 30.2 21.3 17.4 15.6 13.0 0.033 44.5 38.8 Typ 0.069 0.069 0.069 0.069 0.069 0.069 0.032 0.069 0.069 Copyright © 2012-2013 LS Research, LLC TiWi-uB2 Module DATASHEET Average Current Unit 104 µA 121 µA 302 µA 169 µA Max Unit ...

Page 11

... FHSS, GFSK, DPSK, DQPSK -30°C Typ 25°C Typ 9.5 158 138 / dF1 90 avg -95 -93 -86 -5 -10 -10 Table 12 Bluetooth RF Characteristics Copyright © 2012-2013 LS Research, LLC TiWi-uB2 Module DATASHEET 85°C Typ BT Spec 10 10.8 158 158 140~ 175 137 136 >115 ...

Page 12

... Minimum time for nSHUT_DOWN low to reset the device Rise/fall times (1) Internal pull-down retains shutdown mode when no external signal is applied to this pin. The information in this document is subject to change without notice. 330-0100-R1.0 Table 13 nSHUTD Requirements Copyright © 2012-2013 LS Research, LLC TiWi-uB2 Module DATASHEET Symbol Min Max ...

Page 13

... Condition Sym -250 At 1 kHz Integrated over 300 to 15000 Hz 0. VDD_IO Square wave, DC coupled V IL Table 14 32 kHz Clock Requirements Copyright © 2012-2013 LS Research, LLC TiWi-uB2 Module DATASHEET Min Typ Max Unit 32768 250 ppm t /t 100 ...

Page 14

... RTS high to RX_DATA off The information in this document is subject to change without notice. 330-0100-R1.0 Figure 5 Bluetooth HCI UART Timing Condition Hardware flow control Interrupt set to ¼ FIFI Table 15 Bluetooth HCI UART Timing Copyright © 2012-2013 LS Research, LLC TiWi-uB2 Module DATASHEET Min Typ Max Unit 37.5 ...

Page 15

... Figure 6 Bluetooth PCM Timing Condition 166.67 (6 MHz) 50 40pF load 40pF load Table 16 Bluetooth PCM Master Timing Condition 62.5 (16 MHz) 40 40pF load Table 17 Bluetooth PCM Slave Timing Copyright © 2012-2013 LS Research, LLC TiWi-uB2 Module DATASHEET Min Max Unit 15625 (64 kHz) min clk ...

Page 16

... Note: The quality of solder joints on the surface mount pads where they contact the host board should meet the appropriate IPC Specification. See IPC-A-610-D Acceptability of Electronic Assemblies, section 8.2.1 “Bottom Only Terminations.” The information in this document is subject to change without notice. 330-0100-R1.0 Copyright © 2012-2013 LS Research, LLC TiWi-uB2 Module DATASHEET Page ...

Page 17

... Do not store in salty air environment with a high concentration of corrosive gas, such as Cl2, H2S, NH3, SO2, or NOX. Do not store in direct sunlight. The product should not be subject to excessive mechanical shock. Copyright © 2012-2013 LS Research, LLC TiWi-uB2 Module DATASHEET Page ...

Page 18

... Repeating Reflow Soldering Only a single reflow soldering process is encouraged for host boards. The information in this document is subject to change without notice. 330-0100-R1.0 Copyright © 2012-2013 LS Research, LLC TiWi-uB2 Module DATASHEET Page ...

Page 19

... FCC CAUTION: Any changes or modifications not expressly approved by the party responsible for compliance could void the user's authority to operate this equipment. The information in this document is subject to change without notice. 330-0100-R1.0 Copyright © 2012-2013 LS Research, LLC TiWi-uB2 Module DATASHEET Page ...

Page 20

... LS Research 001-0001 center-fed dipole antenna and LS Research 080-0001 U.FL to Reverse Polarity SMA connector cable. 2) Johanson 2450AT43B100 chip antenna. Cet appareil est conforme aux normes d'Industrie Canada exempts de licence RSS (s). L'opération est soumise aux deux conditions suivantes: (1) cet appareil ne peut pas provoquer d'interférences et (2) cet appareil doit accepter toute interfé ...

Page 21

... IC numéro de certification ne peut pas être utilisé sur la produit final. Dans ces circonstances, l'intégrateur OEM sera chargé de réévaluer le produit final (y compris l'émetteur) et l'obtention d'un distincte de la FCC et Industrie Canada l'autorisation. The information in this document is subject to change without notice. 330-0100-R1.0 Copyright © 2012-2013 LS Research, LLC TiWi-uB2 Module DATASHEET Page ...

Page 22

... FCC ID: TFB-BT1" “Contient IC: 5969A-BT1" Les OEM du module TiWi-uB2 ne doit utiliser l'antenne approuvée (s) ci-dessus, qui ont été certifiés avec ce module. The information in this document is subject to change without notice. 330-0100-R1.0 Copyright © 2012-2013 LS Research, LLC TiWi-uB2 Module DATASHEET Page ...

Page 23

... L'intégrateur OEM ne devraient pas fournir des informations à l'utilisateur final sur la façon d'installer ou de supprimer ce module RF ou modifier les paramètres liés RF dans le manuel utilisateur du produit final. Autres déclarations manuel de l'utilisateur peuvent s'appliquer. The information in this document is subject to change without notice. 330-0100-R1.0 Copyright © 2012-2013 LS Research, LLC TiWi-uB2 Module DATASHEET Page ...

Page 24

... The cost for creating an EPL by combination of the Controller Subsystem and Host Subsystem QDIDs is free of charge. See the Bluetooth website for additional details on the EPL process. The information in this document is subject to change without notice. 330-0100-R1.0 Copyright © 2012-2013 LS Research, LLC TiWi-uB2 Module DATASHEET An ...

Page 25

... MECHANICAL DATA The information in this document is subject to change without notice. 330-0100-R1.0 Figure 8 Module Mechanical Dimensions Copyright © 2012-2013 LS Research, LLC TiWi-uB2 Module DATASHEET Page ...

Page 26

... Figure 9 Soldering Footprint for Host Board and Module Placement The information in this document is subject to change without notice. 330-0100-R1.0 Copyright © 2012-2013 LS Research, LLC TiWi-uB2 Module DATASHEET Page ...

Page 27

... Tape & Reel Dimensions The information in this document is subject to change without notice. 330-0100-R1.0 Figure 10 Tape and Reel Specification Copyright © 2012-2013 LS Research, LLC TiWi-uB2 Module DATASHEET Page ...

Page 28

... Tray Dimensions The information in this document is subject to change without notice. 330-0100-R1.0 Figure 11 Tray Specification Copyright © 2012-2013 LS Research, LLC TiWi-uB2 Module DATASHEET Page ...

Page 29

... Taiwan = production year in hex (ex: 2012 = 0A production month in hex (ex: Jul = 7) 567 = last 3 numbers of tracking card in hex YYWW = Date Code (YY=Year, WW=Week Rev 2 The information in this document is subject to change without notice. 330-0100-R1.0 Copyright © 2012-2013 LS Research, LLC TiWi-uB2 Module DATASHEET Page ...

Page 30

... Technical Support Sales Contact The information in this document is provided in connection with LS Research (hereafter referred to as “LSR”) products. No license, express or implied, by estoppel or otherwise, to any intellectual property right is granted by this document or in connection with the sale of LSR products. EXCEPT AS SET FORTH IN LSR’S TERMS AND CONDITIONS OF SALE LOCATED ON LSR’ ...